Assessment of Thermal Degradation by Cumulative Variation of Ultrasonic Nonlinear Parameter
http://link.springer.com/article/10.1007/s12541-017-0003-x
Assessment of thermal degradation by cumulative variation of ultrasonic nonlinear parameter
- Cite this article as:
- Kim, J. & Jhang, KY. Int. J. Precis. Eng. Manuf. (2017) 18: 23. doi:10.1007/s12541-017-0003-x
- 6Downloads
Abstract
The ultrasonic nonlinear parameter β has been studied for the evaluation of material degradation. However, there is a limit to the assessment of degradation induced by thermal aging in aluminum alloy because the nonlinear parameter may fluctuate with the aging time and thus it has not one-to-one correspondence with the thermal degradation. In order to overcome such limitation, we propose a cumulative nonlinear parameter βc defined by the accumulation of variation in the nonlinear parameter over the aging time. For verifying the usefulness of the proposed parameter, two kinds of aluminum alloy specimens heat-treated with different aging temperatures and aging times were tested. After the ultrasonic test has been completed, the tensile test was conducted for all specimens to measure the yield strength as a quantitative index of material degradation. Results showed that the nonlinear parameter β fluctuated in directions of both increase and decrease, while the strength decreased one-sidedly with the increase of aging time. On the other hand, the proposed parameter βc was one-sidedly increased, which showed strong exponential negative correlation with the yield strength. These tendencies were similar in different material and different aging temperature.
-
Full-range stress–strain curve estimation of aluminum alloys using machine learning-aided ultrasound
Date2024.03.19 CategoryInternational Views22 -
Nondestructive Inspection of Directed Energy Deposited Components Using Scanning Acoustic Microscopy with Metalworking Fluids
Date2024.03.19 CategoryInternational Views17 -
Nondestructive Inspection of Cylindrical Components Repaired Via Directed Energy Deposition Using Scanning Acoustic Microscopy with Metal Lubricants
Date2024.03.19 CategoryInternational Views144 -
Plastic properties estimation of aluminum alloys using machine learning of ultrasonic and eddy current data
Date2024.03.19 CategoryInternational Views43 -
Calibration method using a narrowband signal for measurement of the acoustic nonlinearity parameter
Date2024.03.19 CategoryInternational Views21 -
2022.11 한국비파괴검사학회 2022 추계학술대회 우수논문발표상 (유지웅, 송동기, 장경영)
Date2022.11.24 CategoryAward Views553 -
2021.12 한국비파괴검사학회 2021 추계학술대회 우수논문발표상 (한희진, 장경영)
Date2022.11.24 CategoryAward Views457 -
2021.12 한국비파괴검사학회 2021 추계학술대회 우수논문발표상 (방성준, 송동기, 장경영)
Date2022.11.24 CategoryAward Views434 -
Comparisons of second- and third-order ultrasonic nonlinearity parameters measured using through-transmission and pulse-echo methods
Date2022.11.15 CategoryInternational Views2461 -
IJPEM-GT 저널지 편집장 우수논문 선정 (박성현)
Date2022.04.04 CategoryAward Views795 -
2022 산업과학연구소 우수논문상 (박성현)
Date2022.02.21 CategoryAward Views700 -
In-situ and Layer-by-layer Grain Size Estimation of Additively Manufactured Metal Components using Femtosecond Laser Ultrasonic Technique (Submitted)
Date2022.02.21 CategoryInternational Views950 -
Microstructural Characterization of Additively Manufactured Metal Components Using Linear and Nonlinear Ultrasonic Techniques
Date2022.02.21 CategoryInternational Views1269 -
Tensile properties evaluation of additively manufactured Ti-6Al-4V/yttria-stabilized zirconia composite using absolute nonlinear-ultrasonic technique (Submitted)
Date2022.02.21 CategoryInternational Views12454 -
Generation and Measurement of Gigahertz Ultrasonic Waves in Additively Manufactured Thin Metal Components using Femtosecond Laser and Application to In-situ Grain size Monitoring (Submitted)
Date2022.02.21 CategoryInternational Views26186 -
Porosity evaluation of additive manufactured parts: ultrasonic testing and eddy current testing
Date2021.08.25 CategoryDomestic Views124078 -
Nondestructive evaluation of micro-oxide inclusions in additively manufactured metal parts using nonlinear ultrasonic technique
Date2021.08.25 CategoryInternational Views20066 -
Mechanical properties estimation of additively manufactured metal components using femtosecond laser ultrasonics and laser polishing
Date2021.08.25 CategoryInternational Views28911 -
Experimental Verification of Contact Acoustic Nonlinearity at Rough Contact Interfaces
Date2021.08.25 CategoryInternational Views49898 -
Compensation of a Second Harmonic Wave Included in an Incident Ultrasonic Wave for the Precise Measurement of the Acoustic Nonlinearity Parameter
Date2021.08.25 CategoryInternational Views45522 -
Measurement of Absolute Acoustic Nonlinearity Parameter Using Laser-Ultrasonic Detection
Date2021.08.25 CategoryInternational Views43095 -
Rapid Molecular Diagnostic Sensor Based on Ball-Lensed Optical Fibers
Date2021.08.25 CategoryInternational Views36357 -
Porosity Evaluation of Additively Manufactured Components Using Deep Learning‑based Ultrasonic Nondestructive Testing (Editor's pick)
Date2021.08.25 CategoryInternational Views12106 -
Deep Learning-Based Ultrasonic Testing to Evaluate the Porosity of Additively Manufactured Parts with Rough Surfaces
Date2021.08.25 CategoryInternational Views21426 -
Analysis of the influence of surface roughness on measurement of ultrasonic nonlinearity parameter using contact-type transducer
Date2021.08.25 CategoryInternational Views504691 -
Indirect Method for Measuring Absolute Acoustic Nonlinearity Parameter Using Surface Acoustic Waves with a Fully Non-Contact Laser-Ultrasonic Technique
Date2021.08.25 CategoryInternational Views31708 -
Evaluation of yield strength by ultrasonic reconstruction of quadratic nonlinear Stress-Strain curve
Date2021.08.25 CategoryInternational Views65979 -
Ultrasonic nonlinearity parameter in uniaxial stress condition
Date2021.08.25 CategoryInternational Views42978 -
Applicability of nonlinear ultrasonic technique to evaluation of thermally aged CF8M cast stainless steel
Date2021.08.25 CategoryInternational Views7005 -
2021.07 한국비파괴검사학회 2021 춘계학술대회 우수논문발표상 (유지웅, 송동기, 장경영)
Date2021.07.20 CategoryAward Views2217 -
2021.07 한국비파괴검사학회 2021 춘계학술대회 우수논문발표상 (송동기, 장경영)
Date2021.07.20 CategoryAward Views668 -
2020.06 한국비파괴검사학회 비파괴검사학회지 우수논문상 / 2020.07 한국과학기술단체총연합회 과학기술우수논문상 (최성호,김상민,장경영)
Date2020.09.28 CategoryAward Views10759 -
2019.11 한국비파괴검사학회 2019 추계학술대회 우수논문발표상 (박성현, 홍정연, 최성호, 장경영)
Date2020.01.06 CategoryAward Views19543 -
2019.07 한국비파괴검사학회 2019 춘계학술대회 우수논문발표상 (송동기, 류주영, 홍정연, 최성호, 장경영)
Date2020.01.06 CategoryAward Views20737 -
2019.07 한국비파괴검사학회 2019 춘계학술대회 우수논문발표상 (박성현, 심명종, 최성호, 장경영)
Date2020.01.06 CategoryAward Views23062 -
Nondestructive Evaluation of Thermal Aging in Al6061 Alloy by measuring Acoustic Nonlinearity of Laser-generated Surface Acoustic Waves
Date2020.01.06 CategoryInternational Views66343 -
Stress estimation using the acoustoelastic effect of surface waves in weak anisotropic materials
Date2020.01.06 CategoryInternational Views85945 -
Comparison of Linear and Nonlinear Ultrasonic Parameters in Characterizing Grain Size and Mechanical Properties of 304L Stainless Steel
Date2020.01.06 CategoryInternational Views31003 -
Imaging and Sizing of Surface Defects Using Synthetic Aperture Focusing of Laser-generated Surface Waves
Date2020.01.06 CategoryDomestic Views34900 -
2018 산업통상자원부장관 위촉장
Date2019.06.10 CategoryAward Views29368 -
2018.11 비파괴학회 우수포스터상 (이영진,박기태,김종범,김창수,장경영)
Date2018.11.29 CategoryAward Views32354 -
2018.11 비파괴학회 우수논문발표상 (김창수,김종범,송동기,장경영)
Date2018.11.29 CategoryAward Views85724 -
Internal defect detection using laser-generated longitudinal waves in ablation regime
Date2018.11.29 CategoryInternational Views108843 -
Synthetic aperture imaging of contact acoustic nonlinearity to visualize the closing interfaces using tone-burst ultrasonic waves
Date2018.11.28 CategoryInternational Views87706 -
Variation of Acoustoelastic Effect in Al6061-T6 according to Heat Treatment Time
Date2018.11.28 CategoryDomestic Views62382 -
Dependence of Nonlinear Ultrasonic Characteristic on Second-Phase Precipitation in Heat-Treated Al 6061-T6 alloy
Date2018.11.28 CategoryInternational Views74130 -
Relative Measurement of the Acoustic Nonlinearity Parameter using Laser Detection of an Ultrasonic Wave
Date2018.06.14 CategoryInternational Views100108 -
A Method to Estimate the Absolute Ultrasonic Nonlinearity Parameter from Relative Measurements
Date2018.06.14 CategoryInternational Views86793 -
Finite element analysis of a low-velocity impact test for glass fiber-reinforced polypropylene composites considering mixed-mode interlaminar fracture toughness
Date2018.06.14 CategoryInternational Views99123 -
2017년 비파괴검사학회지 우수논문발표상 (하홍필, 김종범, 장경영)
Date2018.02.01 CategoryAward Views50049 -
2017 글로벌박사 펠로우십 (Global Ph.D. Fellowship) 1건 선정 - 전지현 (박사과정)
Date2017.03.23 CategoryAward Views61927 -
2017 글로벌박사 펠로우십 (Global Ph.D. Fellowship) 1건 선정 - 서호건 (박사과정)
Date2017.03.23 CategoryAward Views64633 -
2016년 비파괴검사학회지 우수논문발표상 (박성현, 김종범, 이주호, 장경영)
Date2017.02.28 CategoryAward Views65769 -
Assessment of Thermal Degradation by Cumulative Variation of Ultrasonic Nonlinear Parameter
Date2017.01.16 CategoryInternational Views207680 -
Assessment of Thermal Aging of Aluminum Alloys by Acoustic Nonlinearity Measurement of Surface Acoustic Waves
Date2017.01.16 CategoryInternational Views124092 -
Absolute Measurement and Relative Measurement of Ultrasonic Nonlinear Parameter
Date2017.01.16 CategoryInternational Views302937 -
Experimental Comparison of Nonlinear Parameters Obtained from Absolute Measurement and Relative Measurement
Date2017.01.16 CategoryInternational Views167975 -
Comparison of Ultrasonic Nonlinear Parameters Measured by PZT and LiNbO3 Transducers
Date2017.01.16 CategoryInternational Views140201 -
KSME-SEMES 오픈 이노베이션 챌린지 동상 수상 - 윤성희
Date2016.12.21 CategoryAward Views69541 -
2016 글로벌박사 펠로우십 (Global Ph.D. Fellowship) 1건 선정 - 전지현 (석박사통합과정)
Date2016.09.09 CategoryAward Views67079 -
2016 글로벌박사 펠로우십 (Global Ph.D. Fellowship) 1건 선정 - 서호건 (박사과정)
Date2016.04.09 CategoryAward Views65101 -
JMST - JMST Contribution Award
Date2016.02.23 CategoryAward Views66224 -
Nanotribological and wetting performance of hierarchical patterns
Date2016.02.23 CategoryInternational Views123444 -
2015 산업부장관 표창
Date2015.12.08 CategoryAward Views67608 -
Demonstration of Disturbance Propagation and Amplification in Car-Following Situation for Enhancement of Vehicle Platoon System
Date2015.09.16 CategoryInternational Views147571 -
Relative Measurement of Acoustic Nonlinear Parameters and Comparison of Sensitivity to Thermal Aging
Date2015.09.16 CategoryInternational Views117520 -
Non-contact Measurement of Elastic Modulus by using Laser Ultrasonic
Date2015.09.16 CategoryInternational Views232085 -
Relationship between Second- and Third-order Acoustic Nonlinear Parameters in Relative Measurement
Date2015.09.16 CategoryInternational Views138509 -
Non-Contact Evaluation of Acoustic Nonlinearity of a Laser-Generated Surface Wave in a Plastically Deformed Aluminum Alloy
Date2015.09.16 CategoryInternational Views160028 -
Influence of repetitive pulsed laser irradiation on the surface characteristics of an aluminum alloy in the melting regime
Date2015.09.16 CategoryInternational Views280903 -
Real-time detection of surface cracks on silicon wafers during laser beam irradiation
Date2015.09.16 CategoryInternational Views249439 -
High power CW laser-induced damage of CMOS image sensor
Date2015.09.16 CategoryDomestic Views97759 -
Measurement of Ultrasonic Nonlinear Parameter by Using Non-Contact Ultrasonic Receiver
Date2015.09.16 CategoryDomestic Views96823 -
Study on the Nonlinear Electromagnetic Acoustic Resonance Method for the Evaluation of Hidden Damage in a Metallic Material
Date2015.09.16 CategoryDomestic Views95810 -
Influence of laser beam profiles on the frequency bandwidth of laser-generated surface acoustic waves
Date2015.09.16 CategoryInternational Views121854 -
Laser ultrasonic inspection in ablation regime
Date2015.09.16 CategoryInternational Views132372 -
Improvement of Crack Sizing Performance by using Nonlinear Ultrasonic Technique
Date2015.09.16 CategoryInternational Views104075 -
대한기계학회 - 우수 학생 논문상
Date2015.09.16 CategoryAward Views66695 -
비파괴검사학회지 - 우수논문상
Date2015.09.15 CategoryAward Views67793 -
한국도로공사 교통데이터 공모전 - 대한교통학회 회장상 수상 (김진수)
Date2014.10.15 CategoryAward Views114439 -
In-Line Ultrasonic Monitoring for Sediments Stuck on Inner Wall of a Polyvinyl Chloride Pipe
Date2014.09.29 CategoryInternational Views129242 -
In situ detection of laser-induced slip initiation on the silicon wafer surface
Date2014.09.29 CategoryInternational Views104262 -
Initiation time of near-infrared laser-induced slip on the surface of silicon wafers
Date2014.09.29 CategoryInternational Views112285 -
Evaluation of Ultrasonic Nonlinear Characteristics in Artificially Aged Al6061-T6
Date2014.09.29 CategoryDomestic Views121835 -
Simulations for Internal Defect Inspection using Laser Generated Ultrasonic Wave in Ablation Regime
Date2014.09.29 CategoryDomestic Views128114 -
Slip damage of silicon wafers subjected to continuous infrared laser irradiation
Date2014.09.29 CategoryInternational Views105403 -
Thermal damages on the surface of a silicon wafer induced by a near-infrared laser
Date2014.09.29 CategoryInternational Views637501 -
Feasibility of MFC (Macro-Fiber Composite) Transducers for Guided Wave Technique
Date2014.09.29 CategoryDomestic Views222371 -
Initial Second Harmonic Generation in Narrowband Surface Waves by Multi-Line Laser Beams for Two Kinds of Spatial Energy Profile Models
Date2014.09.29 CategoryDomestic Views125703 -
Evaluation of Ultrasonic Nonlinear Characteristics in Heat-Treated Aluminum Alloy
Date2014.09.29 CategoryDomestic Views118643 -
A6061 합금의 석출경화 열처리에 따른 탄성파의 음향 특성 연구
Date2014.09.29 CategoryDomestic Views124318 -
비파괴검사학회지 - 우수 논문상
Date2014.09.29 CategoryAward Views71609 -
한국ITS학회 - 우수논문상
Date2014.09.29 CategoryAward Views77760 -
Crack Detection in Single-Crystalline Silicon Wafer Using Laser Generated Lamb Wave
Date2014.03.05 CategoryInternational Views139303 -
Evaluation of Ultrasonic Nonlinear Characteristics in Heat-Treated Aluminum Alloy (Al-Mg-Si-Cu)
Date2014.03.05 CategoryInternational Views191751 -
Application of Macrofiber Composite for Smart Transducer of Lamb Wave Inspection
Date2014.03.05 CategoryInternational Views106246 -
Thermal Damage Characterization of Silicon Wafer Subjected to CW Laser Beam
Date2014.03.05 CategoryDomestic Views104307 -
Imaging of contact acoustic nonlinearity using synthetic aperture technique
Date2014.03.05 CategoryInternational Views120705 -
Feasibility of MFC (Macro-Fiber Composite) Transducers for Guided Wave Technique
Date2014.03.05 CategoryDomestic Views111629 -
Initial Second Harmonic Generation in Narrowband Surface Waves by Multi-Line Laser Beams for Two Kinds of Spatial Energy Profile
Date2014.03.05 CategoryDomestic Views132035