Assessment of Thermal Degradation by Cumulative Variation of Ultrasonic Nonlinear Parameter
http://link.springer.com/article/10.1007/s12541-017-0003-x
Assessment of thermal degradation by cumulative variation of ultrasonic nonlinear parameter
- Cite this article as:
- Kim, J. & Jhang, KY. Int. J. Precis. Eng. Manuf. (2017) 18: 23. doi:10.1007/s12541-017-0003-x
- 6Downloads
Abstract
The ultrasonic nonlinear parameter β has been studied for the evaluation of material degradation. However, there is a limit to the assessment of degradation induced by thermal aging in aluminum alloy because the nonlinear parameter may fluctuate with the aging time and thus it has not one-to-one correspondence with the thermal degradation. In order to overcome such limitation, we propose a cumulative nonlinear parameter βc defined by the accumulation of variation in the nonlinear parameter over the aging time. For verifying the usefulness of the proposed parameter, two kinds of aluminum alloy specimens heat-treated with different aging temperatures and aging times were tested. After the ultrasonic test has been completed, the tensile test was conducted for all specimens to measure the yield strength as a quantitative index of material degradation. Results showed that the nonlinear parameter β fluctuated in directions of both increase and decrease, while the strength decreased one-sidedly with the increase of aging time. On the other hand, the proposed parameter βc was one-sidedly increased, which showed strong exponential negative correlation with the yield strength. These tendencies were similar in different material and different aging temperature.
-
Thermal damages on the surface of a silicon wafer induced by a near-infrared laser
Date2014.09.29 CategoryInternational Views638060 -
Analysis of the influence of surface roughness on measurement of ultrasonic nonlinearity parameter using contact-type transducer
Date2021.08.25 CategoryInternational Views506179 -
Absolute Measurement and Relative Measurement of Ultrasonic Nonlinear Parameter
Date2017.01.16 CategoryInternational Views303087 -
Influence of repetitive pulsed laser irradiation on the surface characteristics of an aluminum alloy in the melting regime
Date2015.09.16 CategoryInternational Views282290 -
Real-time detection of surface cracks on silicon wafers during laser beam irradiation
Date2015.09.16 CategoryInternational Views249558 -
Non-contact Measurement of Elastic Modulus by using Laser Ultrasonic
Date2015.09.16 CategoryInternational Views232568 -
Feasibility of MFC (Macro-Fiber Composite) Transducers for Guided Wave Technique
Date2014.09.29 CategoryDomestic Views222684 -
Assessment of Thermal Degradation by Cumulative Variation of Ultrasonic Nonlinear Parameter
Date2017.01.16 CategoryInternational Views207844 -
Evaluation of Ultrasonic Nonlinear Characteristics in Heat-Treated Aluminum Alloy (Al-Mg-Si-Cu)
Date2014.03.05 CategoryInternational Views191757 -
Imaging of Harmonic Wave Generated by Contact Acoustic Nonlinearity in Obliquely Incident Ultrasonic Wave
Date2014.03.05 CategoryDomestic Views191622 -
Surface characteristics of aluminum 6061-T6 subjected to Nd:YAG pulsed-laser irradiation
Date2012.06.21 CategoryInternational Views187655 -
Non-contact Single-Mode Guided Wave Technique by the Combination of Wavelength-Matched Laser Generation and Angle-Matched Leak Wave Detection
Date2012.05.03 CategoryInternational Views183062 -
Experimental Comparison of Nonlinear Parameters Obtained from Absolute Measurement and Relative Measurement
Date2017.01.16 CategoryInternational Views168174 -
Finite Difference Method Analysis of Ultrasonic Nonlinearity in Partially Degraded Material
Date2012.05.03 CategoryInternational Views160357 -
Non-Contact Evaluation of Acoustic Nonlinearity of a Laser-Generated Surface Wave in a Plastically Deformed Aluminum Alloy
Date2015.09.16 CategoryInternational Views160137 -
Fatigue-induced microdamage characterization of stainless steel 316L using innovative nonlinear acoustics
Date2012.06.21 CategoryInternational Views148326 -
Demonstration of Disturbance Propagation and Amplification in Car-Following Situation for Enhancement of Vehicle Platoon System
Date2015.09.16 CategoryInternational Views147705 -
Single-mode guided wave technique using ring-arrayed laser beam for thin-tube inspection
Date2012.05.03 CategoryInternational Views144486 -
모드선택성을 강화한 비접촉식 유도초음파 기술
Date2012.05.03 CategoryDomestic Views143304 -
Comparison of Ultrasonic Nonlinear Parameters Measured by PZT and LiNbO3 Transducers
Date2017.01.16 CategoryInternational Views140263