Assessment of Thermal Degradation by Cumulative Variation of Ultrasonic Nonlinear Parameter
http://link.springer.com/article/10.1007/s12541-017-0003-x
Assessment of thermal degradation by cumulative variation of ultrasonic nonlinear parameter
- Cite this article as:
- Kim, J. & Jhang, KY. Int. J. Precis. Eng. Manuf. (2017) 18: 23. doi:10.1007/s12541-017-0003-x
- 6Downloads
Abstract
The ultrasonic nonlinear parameter β has been studied for the evaluation of material degradation. However, there is a limit to the assessment of degradation induced by thermal aging in aluminum alloy because the nonlinear parameter may fluctuate with the aging time and thus it has not one-to-one correspondence with the thermal degradation. In order to overcome such limitation, we propose a cumulative nonlinear parameter βc defined by the accumulation of variation in the nonlinear parameter over the aging time. For verifying the usefulness of the proposed parameter, two kinds of aluminum alloy specimens heat-treated with different aging temperatures and aging times were tested. After the ultrasonic test has been completed, the tensile test was conducted for all specimens to measure the yield strength as a quantitative index of material degradation. Results showed that the nonlinear parameter β fluctuated in directions of both increase and decrease, while the strength decreased one-sidedly with the increase of aging time. On the other hand, the proposed parameter βc was one-sidedly increased, which showed strong exponential negative correlation with the yield strength. These tendencies were similar in different material and different aging temperature.
-
Fully Non-Contact Assessment of Acoustic Nonlinearity According to Plastic Deformation in Al6061 Alloy
Date2014.03.05 CategoryDomestic Views135370 -
"Acoustic Nonlinearity of Surface Wave in a Fatigued Aluminum Alloy Specimen "
Date2012.05.03 CategoryInternational Views135693 -
Relationship between Second- and Third-order Acoustic Nonlinear Parameters in Relative Measurement
Date2015.09.16 CategoryInternational Views138589 -
Crack Detection in Single-Crystalline Silicon Wafer Using Laser Generated Lamb Wave
Date2014.03.05 CategoryInternational Views139440 -
2013 글로벌박사펠로우십 신규 사업 2 건 최종 선정 (박사과정 김진수, 석박통합과정 서호건)
Date2013.06.19 CategoryAward Views139673 -
인듐안티모나이드(InSb) 소자를 이용한 적외선 방사온도 계측시스템의 개발 연구
Date2012.05.03 CategoryDomestic Views139797 -
Comparison of Ultrasonic Nonlinear Parameters Measured by PZT and LiNbO3 Transducers
Date2017.01.16 CategoryInternational Views140278 -
모드선택성을 강화한 비접촉식 유도초음파 기술
Date2012.05.03 CategoryDomestic Views143322 -
Single-mode guided wave technique using ring-arrayed laser beam for thin-tube inspection
Date2012.05.03 CategoryInternational Views144514 -
Demonstration of Disturbance Propagation and Amplification in Car-Following Situation for Enhancement of Vehicle Platoon System
Date2015.09.16 CategoryInternational Views147733 -
Fatigue-induced microdamage characterization of stainless steel 316L using innovative nonlinear acoustics
Date2012.06.21 CategoryInternational Views148368 -
Non-Contact Evaluation of Acoustic Nonlinearity of a Laser-Generated Surface Wave in a Plastically Deformed Aluminum Alloy
Date2015.09.16 CategoryInternational Views160156 -
Finite Difference Method Analysis of Ultrasonic Nonlinearity in Partially Degraded Material
Date2012.05.03 CategoryInternational Views160387 -
Experimental Comparison of Nonlinear Parameters Obtained from Absolute Measurement and Relative Measurement
Date2017.01.16 CategoryInternational Views168197 -
Non-contact Single-Mode Guided Wave Technique by the Combination of Wavelength-Matched Laser Generation and Angle-Matched Leak Wave Detection
Date2012.05.03 CategoryInternational Views183063 -
Surface characteristics of aluminum 6061-T6 subjected to Nd:YAG pulsed-laser irradiation
Date2012.06.21 CategoryInternational Views187694 -
Imaging of Harmonic Wave Generated by Contact Acoustic Nonlinearity in Obliquely Incident Ultrasonic Wave
Date2014.03.05 CategoryDomestic Views191717 -
Evaluation of Ultrasonic Nonlinear Characteristics in Heat-Treated Aluminum Alloy (Al-Mg-Si-Cu)
Date2014.03.05 CategoryInternational Views191759 -
Assessment of Thermal Degradation by Cumulative Variation of Ultrasonic Nonlinear Parameter
Date2017.01.16 CategoryInternational Views207904 -
Feasibility of MFC (Macro-Fiber Composite) Transducers for Guided Wave Technique
Date2014.09.29 CategoryDomestic Views222747 -
Non-contact Measurement of Elastic Modulus by using Laser Ultrasonic
Date2015.09.16 CategoryInternational Views232652 -
Real-time detection of surface cracks on silicon wafers during laser beam irradiation
Date2015.09.16 CategoryInternational Views249572 -
Influence of repetitive pulsed laser irradiation on the surface characteristics of an aluminum alloy in the melting regime
Date2015.09.16 CategoryInternational Views282527 -
Absolute Measurement and Relative Measurement of Ultrasonic Nonlinear Parameter
Date2017.01.16 CategoryInternational Views303124 -
Analysis of the influence of surface roughness on measurement of ultrasonic nonlinearity parameter using contact-type transducer
Date2021.08.25 CategoryInternational Views506545 -
Thermal damages on the surface of a silicon wafer induced by a near-infrared laser
Date2014.09.29 CategoryInternational Views638239