In situ detection of laser-induced slip initiation on the silicon wafer surface
http://www.ncbi.nlm.nih.gov/pubmed/25121706
In situ detection of laser-induced slip initiation on the silicon wafer surface.
Abstract
We propose a real-time in situ method to detect slip initiation on the surface of silicon wafers during high-power laser beam irradiation. In this method, light is collected from the surface of a silicon wafer subjected to laser irradiation. When the slip is initiated, it strongly scatters the laser beam, allowing detection of the time of the slip initiation based on the resulting sudden increase in the scattering signal. To demonstrate the performance of this method, a silicon wafer specimen was illuminated by a near-infrared continuous-wave fiber laser beam (of wavelength 1070 nm) at four different laser powers, and the scattered light was detected. The scattering signal increased suddenly at the time of slip initiation. To confirm the occurrence of slip, the surface morphologies of the silicon specimens after laser irradiation were analyzed using an optical microscope; surface slips were observed only in the specimens for which the sudden increase in scattering had been detected. Thus, the proposed method is shown to be very effective for the real-time in situ detection of surface slip initiation induced by high-power laser beam irradiation on silicon wafers.
-
A noncontact NDE method using a laser generated focused-Lamb wave with enhanced defect-detection ability and spation resolution
-
"2.25Cr-1Mo강의 열화도 평가를 위한 비선형 음향효과 응용법"
-
Nonlinear Ultrasonic Method to Detect Micro-delamination in Electronic Packaging
-
Application of Macrofiber Composite for Smart Transducer of Lamb Wave Inspection
-
Advanced Technologies for Estimation of Nonlinear Ultrasonic Parameter
-
Evaluation of material degrading using nonlinear acoustic effect
-
Slip damage of silicon wafers subjected to continuous infrared laser irradiation
-
자동 초점 기법을 이용한 유리 내부 결함 검출
-
Detection of Micro-Delamination in Electronic Packaging by Using the Ultrasonic Nonlinearity
-
Application of Nonlinear Ultrasonics to the NDE of Material Degradation
-
NONLINEAR BEHAVIOR OF ULTRASONIC WAVE AT CRACK
-
Estimation of Nonlinear Acoustic Parameter Using Bispectral Analysis
-
Thermal Damage Characterization of Silicon Wafer Subjected to CW Laser Beam
-
In situ detection of laser-induced slip initiation on the silicon wafer surface
-
Research on the Nondestructive Measurement of Nonlinear Elastic Modulus by using Ultrasonic Wave
-
비선형 응향효과에 의한 고온재료의 파괴인성 열화도 평가
-
Improvement of Crack Sizing Performance by using Nonlinear Ultrasonic Technique
-
레이저에 의한 집속형 램파의 집속도 향상을 위한 원호형 슬릿 설계
-
SNR Improvement of AE Signal for Detection of Gas Leak from Tubes under Vibratory Environment
-
Imaging of Defects in Thin Plate by Scanning of Laser-generated Focused-Lamb Waves