댓글 0조회 수 8131추천 수 0
?

단축키

이전 문서

다음 문서

+ - Up Down Comment Print
?

단축키

이전 문서

다음 문서

+ - Up Down Comment Print

http://link.springer.com/article/10.1007/s12541-017-0003-x


Assessment of thermal degradation by cumulative variation of ultrasonic nonlinear parameter

  1. 1.
  2. 2.
Article

DOI: 10.1007/s12541-017-0003-x

Cite this article as:
Kim, J. & Jhang, KY. Int. J. Precis. Eng. Manuf. (2017) 18: 23. doi:10.1007/s12541-017-0003-x
  • 6Downloads

Abstract

The ultrasonic nonlinear parameter β has been studied for the evaluation of material degradation. However, there is a limit to the assessment of degradation induced by thermal aging in aluminum alloy because the nonlinear parameter may fluctuate with the aging time and thus it has not one-to-one correspondence with the thermal degradation. In order to overcome such limitation, we propose a cumulative nonlinear parameter βc defined by the accumulation of variation in the nonlinear parameter over the aging time. For verifying the usefulness of the proposed parameter, two kinds of aluminum alloy specimens heat-treated with different aging temperatures and aging times were tested. After the ultrasonic test has been completed, the tensile test was conducted for all specimens to measure the yield strength as a quantitative index of material degradation. Results showed that the nonlinear parameter β fluctuated in directions of both increase and decrease, while the strength decreased one-sidedly with the increase of aging time. On the other hand, the proposed parameter βc was one-sidedly increased, which showed strong exponential negative correlation with the yield strength. These tendencies were similar in different material and different aging temperature.


분류 제목 조회 수
Award 2017 글로벌박사 펠로우십 (Global Ph.D. Fellowship) 1건 선정 - 전지현 (박사과정)     3662
Award 2017 글로벌박사 펠로우십 (Global Ph.D. Fellowship) 1건 선정 - 서호건 (박사과정)     3609
Workshop 제 5차 잠닉손상진단 핵심기술개발 Workshop  fileimage   4046
Award 2016년 비파괴검사학회지 우수논문발표상 (박성현, 김종범, 이주호, 장경영)  fileimage   4097
International Assessment of Thermal Degradation by Cumulative Variation of Ultrasonic Nonlinear Parameter     8131
International Assessment of Thermal Aging of Aluminum Alloys by Acoustic Nonlinearity Measurement of Surface Acoustic Waves     7706
International Absolute Measurement and Relative Measurement of Ultrasonic Nonlinear Parameter     8161
International Experimental Comparison of Nonlinear Parameters Obtained from Absolute Measurement and Relative Measurement     7384
International Comparison of Ultrasonic Nonlinear Parameters Measured by PZT and LiNbO3 Transducers     7210
Award KSME-SEMES 오픈 이노베이션 챌린지 동상 수상 - 윤성희  fileimage   4876
Award 2016 글로벌박사 펠로우십 (Global Ph.D. Fellowship) 1건 선정 - 전지현 (석박사통합과정)  fileimage   6170
Award 2016 글로벌박사 펠로우십 (Global Ph.D. Fellowship) 1건 선정 - 서호건 (박사과정)     6292
Domestic Effect of Window Function to Measurement of Ultrasonic Nonlinear Parameter using Fast Fourier Transform of Tone-burst Signal     7948
Award JMST - JMST Contribution Award  fileimage   6113
Workshop Yoshikazu Ohara 교수 초청 세미나  fileimage   5945
Workshop Takahiro Hayashi 교수 초청 세미나  fileimage   5834
International Nanotribological and wetting performance of hierarchical patterns     9349
Workshop 제 4차 잠닉손상 진단 핵심기술개발 Workshop  fileimage   5847
Award 2015 산업부장관 표창  fileimage   6523
Workshop 제3차 잠닉손상 진단 핵심기술개발 Workshop  fileimage   6065
Workshop 김진연 박사 초청 세미나 "Advanced Ultrasonic Testingbased on Acoustic Nonlinearity Measurement for NDE"  fileimage   7552
Workshop 제2차 잠닉손상 진단 핵심기술개발 Workshop  fileimage   6078
Workshop 2차년도 잠닉손상진단 핵심기술개발 1세부과제 진행 회의  fileimage   6414
Workshop 잠닉손상 진단 핵심기술개발 2차년도 kick-off Meeting  fileimage   6446
Workshop The Workshop on Current & Future of Nonlninear Ultrasonic Techniques for NDE  fileimage   5938
Workshop The Pre-workshop on Current and Future of Nonlinear Ultrasonic Techniques for NDE  fileimage   6094
Workshop 잠닉손상 진단 핵심원천기술 개발 연구 Workshop  fileimage   5970
Workshop 잠닉손상 진단 핵심원천기술 개발 – 1세부 진도회의  fileimage   5949
Workshop 잠닉손상 진단 핵심원천기술 개발 Kick-off Meeting  fileimage   6068
Workshop Ultrasonic & Electromagnetic Waves for NDE and SHM  fileimage   5942
International Demonstration of Disturbance Propagation and Amplification in Car-Following Situation for Enhancement of Vehicle Platoon System     9943
International Relative Measurement of Acoustic Nonlinear Parameters and Comparison of Sensitivity to Thermal Aging     9817
International Non-contact Measurement of Elastic Modulus by using Laser Ultrasonic     11402
International Relationship between Second- and Third-order Acoustic Nonlinear Parameters in Relative Measurement     9923
International Non-Contact Evaluation of Acoustic Nonlinearity of a Laser-Generated Surface Wave in a Plastically Deformed Aluminum Alloy     9431
International Influence of repetitive pulsed laser irradiation on the surface characteristics of an aluminum alloy in the melting regime     10085
International Real-time detection of surface cracks on silicon wafers during laser beam irradiation     10117
Domestic High power CW laser-induced damage of CMOS image sensor     10215
Domestic Measurement of Ultrasonic Nonlinear Parameter by Using Non-Contact Ultrasonic Receiver     10169
Domestic Study on the Nonlinear Electromagnetic Acoustic Resonance Method for the Evaluation of Hidden Damage in a Metallic Material     10050
International Influence of laser beam profiles on the frequency bandwidth of laser-generated surface acoustic waves     9694
International Laser ultrasonic inspection in ablation regime     9576
International Improvement of Crack Sizing Performance by using Nonlinear Ultrasonic Technique     10068
Award 대한기계학회 - 우수 학생 논문상  fileimage   6138
Award 비파괴검사학회지 - 우수논문상  fileimage   5876
Award 한국도로공사 교통데이터 공모전 - 대한교통학회 회장상 수상 (김진수)  fileimage   27655
International In-Line Ultrasonic Monitoring for Sediments Stuck on Inner Wall of a Polyvinyl Chloride Pipe     18091
International In situ detection of laser-induced slip initiation on the silicon wafer surface     19058
International Initiation time of near-infrared laser-induced slip on the surface of silicon wafers     18768
Domestic Evaluation of Ultrasonic Nonlinear Characteristics in Artificially Aged Al6061-T6     18284
Domestic Simulations for Internal Defect Inspection using Laser Generated Ultrasonic Wave in Ablation Regime     20180
International Slip damage of silicon wafers subjected to continuous infrared laser irradiation     18571
International Thermal damages on the surface of a silicon wafer induced by a near-infrared laser     17651
Domestic Feasibility of MFC (Macro-Fiber Composite) Transducers for Guided Wave Technique     17879
Domestic Initial Second Harmonic Generation in Narrowband Surface Waves by Multi-Line Laser Beams for Two Kinds of Spatial Energy Profile Models     17487
Domestic Evaluation of Ultrasonic Nonlinear Characteristics in Heat-Treated Aluminum Alloy     17533
Domestic A6061 합금의 석출경화 열처리에 따른 탄성파의 음향 특성 연구     20665
Award 비파괴검사학회지 - 우수 논문상  fileimage   12802
Award 한국ITS학회 - 우수논문상  fileimage   15880
International Crack Detection in Single-Crystalline Silicon Wafer Using Laser Generated Lamb Wave     23797
International Evaluation of Ultrasonic Nonlinear Characteristics in Heat-Treated Aluminum Alloy (Al-Mg-Si-Cu)     85198
International Application of Macrofiber Composite for Smart Transducer of Lamb Wave Inspection     23860
Domestic Thermal Damage Characterization of Silicon Wafer Subjected to CW Laser Beam     23986
International Imaging of contact acoustic nonlinearity using synthetic aperture technique     23594
Domestic Feasibility of MFC (Macro-Fiber Composite) Transducers for Guided Wave Technique     23846
Domestic Initial Second Harmonic Generation in Narrowband Surface Waves by Multi-Line Laser Beams for Two Kinds of Spatial Energy Profile     23651
Domestic Evaluation of Ultrasonic Nonlinear Characteristics in Heat-Treated Aluminum Alloy     22819
International Influence of slit width on harmonic generation in ultrasonic surface waves excited by masking a laser beam with a line arrayed slit     23511
International Acoustic Nonlinearity of a Laser-Generated Surface Wave in a Plastically Deformed Aluminum Alloy     22783
International Analysis of Transmitted Ultrasound signals through Apples at Different Storage Times using the Continuous Wavelet Transformation     22307
Domestic Fully Non-Contact Assessment of Acoustic Nonlinearity According to Plastic Deformation in Al6061 Alloy     23095
Domestic Imaging of Harmonic Wave Generated by Contact Acoustic Nonlinearity in Obliquely Incident Ultrasonic Wave     22618
Domestic Frequency Characteristics of Surface Wave Generated by Single-Line Pulsed Laser Beam with Two Kinds of Spatial Energy Profile Models: Gaussian and Square-Like     22794
International Harmonic generation of an obliquely incident ultrasonic wave in solid-solid contact interfaces     22553
International NDE of low-velocity impact damages in composite laminates using ESPI, digital shearography and ultrasound C-scan techniques     21788
Award Best Poster Award, 3rd International Symposium on Laser Ultrasonics and Advanced Sensing (Sungho Choi)     20470
Award Best Student Poster Presentation Award: FIRST PRIZE, 9th FEOFS (Sung-ho Choi)  fileimage   25897
Award 2013 글로벌박사펠로우십 신규 사업 2 건 최종 선정 (박사과정 김진수, 석박통합과정 서호건)     48496
Award 비파괴검사학회지 우수 논문상 (김정석, 남태형, 최성호, 장경영)  fileimage   17925
Workshop 2012 첨단 비파괴 진단 기술 워크샵, 제주도  fileimage   18175
Domestic B-mode Imaging of second Harmonic Amplitude induced by CAN at Contact Interface  file   53712
International Surface characteristics of aluminum 6061-T6 subjected to Nd:YAG pulsed-laser irradiation     30798
International Fatigue-induced microdamage characterization of stainless steel 316L using innovative nonlinear acoustics     29883
International Harmonic generation of an obliquely incident ultrasonic wave in solid-solid contact interfaces     30604
International Ultrasonic Characterization for directional coarsening in nickel-base superalloy during creep exposure     30676
International Frequency Response of Narrowband Surface Waves Generated by Laser Beams Spatially Modulated with a Line-arrayed Slit Mask     29849
International "Acoustic Nonlinearity of Surface Wave in a Fatigued Aluminum Alloy Specimen "     30843
International Nonliner Ultrasonic Characterization of fatigue damage in sus316L alloy     29756
International Wetting behavior and nanotribological properties of silicon nanopatterns combined with diamond-like carbon and perfluoropolyther films     29860
International " Bending Fatigue Evaluation of Al6061 Alloy by Laser-generated Surface Wave"     30202
International CREEP CHARACTERIZATION OF SUPERALLOY IN-738 USING ULTRASONICC NONLINEARITY MEASUREMENT     29878
International Acoustic Nonlinearity of Narrowband Lager-generated Surface Waves in the Bending Fatigue of Al6061 alloy.     29461
International CHARACTERIZATION OF TAINLESS STEEL FIBER REINFORCED ALUMINUM COMPOSITE USING ULTRASONIC NONLINEARITY     28430
International EVALUATION OF FATIGUE DEGRADATION USING NONLINEAR ULTRASONICS     26702
International NONLINEAR BEHAVIOR OF ULTRASONIC WAVE AT CRACK     28432
International Experimental investigation of nonlinear acoustic effect at crack     26627
International Nonlinear ultrasonic characterization of thermal degradation in ferritic 2.25Cr-1Mo steel     36833
International Nonlinear Ultrasonic Techniques for Nondestructive Assessment of Micro Damage in Material : Review     29466
International Single-mode guided wave technique using ring-arrayed laser beam for thin-tube inspection     30081
International The Nonlinearity of Guided Wave in an Elastic Plate     28049
Board Pagination ‹ Prev 1 2 Next ›
/ 2
Designed by hikaru100

나눔글꼴 설치 안내


이 PC에는 나눔글꼴이 설치되어 있지 않습니다.

이 사이트를 나눔글꼴로 보기 위해서는
나눔글꼴을 설치해야 합니다.

설치 취소

SketchBook5,스케치북5

SketchBook5,스케치북5

SketchBook5,스케치북5

SketchBook5,스케치북5

ISNDE Laboratory
203-2,Engineering Center Annex
Hanyang University,
222 Wangsimni-ro, Seongdong-gu
Seoul 04763, Korea
04763 서울특별시 성동구 왕십리로 222
한양대학교 공업센터 별관 203-2호
지능계측 및 비파괴평가 연구실
Tel: 02 - 2220 - 4220
Fax: 02 - 2299 - 7207